Truck TireMoni product catalog 2014: intelligent tyre pressure monitoring systems for trucks and busses for fast and easy retrofit. Drive safely, arrive safely: Every Time. Save fuel and prevent blowouts: Clever. Reduce operating cost and increase service quality with a small investement with sort ROI.
Top profile Call Girls In Anand [ 7014168258 ] Call Me For Genuine Models We ...
Truck TireMoni product catalog 2014 in English
1. TireMoni Truck TPMS
intelligent tyre pressure monitoring systems
for fast and easy installation!
Drive safely, arrive safely.
Every time!
Save fuel, prevent blowouts.
Clever!
2. tpm-systems AG
Tyre Pressure Monitoring
Cost and Usability Aspects for Commercial Vehicles
Correct tyre pressure provides four benefits!
Incorrect tyre pressure increases your operating
cost and can be dangerous, too.
With too little air in your tyres you will face excessive wear and in the end there is the risk of a break
down. At the same time, overinflated tyres and excessive load will also reduct your mileage.
The diagram on the right clearly shows:
20% too much load or 20% too little pressure will
increase tyre wear by around 20%, i.e. you are only
using 80% of maximum possible mileage.
Bildnachweis: www.michelintransport.com >
The impact on fuel consumption is just as serious. Produkt-Informationen > Der Luftdruck
Studies by Shell, VDA, Wabco et. al. are agreeing on 2,5% higher fuel consumption at 20% below rated pressure. This percentage increases up to 8%
for lower pressures.
The third aspect is maintenance cost:
Thorough tyre maintenance costs time: ca. 60 - 90 seconds per wheel and
costs are repeating typically once a week. With labor costs of 15 - 20 Euro per
hour, your yearly total per vehicle accumulates ca. 750 Euro.
Finally there is the cost for neglected maintenance which will lead to more frequent tyre failures than with regular maintenance or with monitored tyres.
These tyre failures are very costly when they occur. Costs of 1500 Euro per
event are common; and in many cases there will be additional costs for the
downtime of the vehicle plus penalties for failing to meet delivery commitments.
With a tyre pressure monitoring system all four aspects will be improved:
The tyre pressures are permanently monitored and (via a telematics system) it
can be added as a parameter to the cost accounting; this adds another important variable to your calculations and MIS.
The result: improved competitiveness in an ever narrower market and an improved bottom line without much effort.
Typical ROI is achieved after only 6 - 9 months.
The acquisition cost for TireMoni Truck TPMS can be subsidized under the DeMinimis Program (Germany) as safety equipment; this reduces your ROI by
another very large factor.
tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com
Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com
3. tpm-systems AG
LED Pressure Alarm
Optical-electronic tyre pressure monitoring sensors
The valve cap warns with a red flashing light
when the pressure in your tyre is too low.
LED pressure alarm is a strong tool to prevent
flat tyres and to reduce operating costs (fuel
consumption, tyre wear); at the same time driving safety is improved considerably.
The sensor is installed on the valve in place of
the valve cap; during installation it automatically calibrates to the pressure present in the
tyre and monitors it permanently.
If the pressure drops by more than 0,5 Bar, the
sensor warns by a red flashing light. The LED
is clearly visible for 20 m even in daylight.
Pressure variations as a result of temperature
changes are automatically compensated - no
false warnings. Anti theft protection is included
in the design.
Highlights:
✔ Automatic calibration during installation
✔ Clearly visible warning
✔ Temperature compensation “by Design”
✔ Integrated anti theft protection
✔ Batteries replaceable (Service-Kit)
The sensor caps are very robust and are
installed in three easy steps:
1) Inflate cold tyre to required cold
inflation pressure.
2) Install the LED Pressure Alarm sensor
onto the valve using the key.
3) Check the sensor for tightness with
leak-spray.
Article-No.:
LPA-HV-B
LPA-HV-BL6
Description
LED Pressure Alarm single
LED Pressure Alarm 6-pack
tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com
Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com
4. tpm-systems AG
The complete and flexible
Tyre Pressure Monitoring System
1
w 01
Ne n 2
io
rs
Ve
Truck TPMS
Advantages:
• Specially designed for trucks and large commercial vehicles
• Easy handling of trailer changes using Smart-Booster
• Monitors up to 38 wheels per system
• Increases safety on the road and reliability
• Reduces fuel consumption and CO2 emission
• Increases tyre lifetime
• Real-Time information about tyre pressure and temperature
• Facilitates ‘CSR’ (Corporate Social Responsibility)
• 3 low pressure warning threshold levels
• Visual and acoustic alarm for rapid pressure loss
• Visual and acoustic alarm for overpressure
• Visual and acoustic alarm for overtemperature
Article-No.:
10.01.012
10.01.018
10.01.041
10.01.040
10.01.021
10.01.030
Description
TPMS Monitor for installation with suction cup
TPMS Monitor for installation in DIN slot
External antenna, cable length 10 m
Sensor for Truck TPMS
SmartBooster for trailer operation
Hand programmier- and reader tool
tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com
Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com
5. tpm-systems AG
new Design, improved Data Transmission
Specifications
Monitor
Frequency:
Receiver sensitivity:
Display:
Operating temperature:
Operating voltage:
Dimensions:
Article number:
434.1 MHz
-105 dBm
LCD, adjustable
backlight
-30 °C ~ +75 °C
12 V or 24 V
104 x 65 x 25 mm
10.01.012
Sensor
Frequency:
TX power:
Lifetime:
Measurement range:
Measurement accuracy:
Operating temperature:
Dimensions:
Article number:
434.1 MHz
0 dBm
4 - 5 years
0 – 13 Bar
± 0.15 Bar
-40 °C ~ +135 °C
Ø 27,5 x 32,5 mm
10.01.040
Smart Booster
Frequency:
Receiver sensitivity:
TX power:
Operating temperature:
Operating voltage:
Dimensions:
Article number:
434.1 MHz
-105 dBm
0 dBm
-40 °C ~ +85 °C
24 V
203x123x51 mm
10.01.021
Hand Tool
Frequency:
Receiver sensitivity:
TX power:
Operating voltage:
Operating temperature:
Dimensions:
Article number:
434.1 MHz
-95 dBm
0 dBm
9V
-30 °C ~ +75 °C
210x110x30 mm
10.01.030
tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com
Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com
w!
Ne
Truck TPMS
6. tpm-systems AG
The Tyre Pressure Monitoring System for
Integration into Onboard-Telematic-Systems
Advantages:
• RS232 or CAN Interfaces allows integration with Telematic-systems
• Realtime monitoring of pressure and temperature
• Alarm for fast pressure loss
• Multi-stage pressure alarm for pressure loss (3 stages)
• Pressure alarm for high pressure
• Alarm for high temperature and sensor problem
• Readable warnings log
• Smart-Booster for easy trailer changes
• Custom modifications possible
• Central cost monitoring and analysis
• Controllable and predictable maintenance
Article-No.:
10.01.016
10.01.017
10.01.019
10.01.041
10.01.040
10.01.021
10.01.030
Description
Monitor with RS232 interface
Monitor with RS232 interface, custom software
Monitor with CAN-Bus interface
External antenna, cable length 10 m
Sensor for truck TPMS
SmartBooster for trailer operation
Hand programming- and reading tool
tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com
Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com
w!
Ne
Telematic TPMS
7. tpm-systems AG
For Road-Trains and Interlinks,
Low Beds and Special Vehicles
Advantages:
• Special design for commercial vehicles with more than one trailer or
several segments
• Monitors up to 8 trailers and 180 wheels
• Improves safety on the road and reliability
• Reduces fuel consumption
• Increases tyre lifetime
• Realtime information about tyre pressure and temperature
• Facilitates ‘CSR’ (Corporate Social Responsibility)
• Acoustic and visual alarm for fast pressure loss
• 3 pressure warning levels
• Acoustic and visual alarm for high pressure
• Acoustic and visual alarm for high temperature
Article-No.:
10.01.210
10.01.041
10.01.221
10.01.040
10.01.130
Description
RT-TPMS monitor
External antenna, cable length 10 m
RT-Smart Booster, 24V
Truck TPMS sensor
RT-Hand programming- and reading tool
tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com
Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com
w!
Ne
TPMS-RT
8. tpm-systems AG
w!
Ne
Bus TPMS
for Citybus, Service Buses, Coaches
Advantages:
• Reduces fuel consumption, CO2 emissions and tyre wear
• Improves driving safety
• In-slot display blends in with the dashboard
Functions:
• Low pressure alarm, hi-pressure alarm, alarm for fast pressure loss
• Easy to install; suitable for manufacturer installation
• Connection to permanent Vcc enables continuous monitoring
Alarm-Functions:
• Low pressure alarm: Level 1: -12.5 %; Level 2: -25 %; Level 3: -50 %
• Fast leak alarm: when pressure loss > 0,2 Bar within 12 seconds
• High pressure alarm: at +25 %
• Transmitter problem alarm: when the transmitter is no longer working or
in case of radio interferences
• High temperature alarm: at more than 90°C
tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com
Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com
9. tpm-systems AG
w!
Ne
Bus TPMS
for a safe and relaxed journey
Specifications:
Monitor
Frequency:
Receiver sensitivity:
Operating temperature:
Operating voltage:
Dimensions:
Article number:
434.1 MHz
-105 dBm
-30 °C ~ +85 °C
12 V oder 24 V
132 x 99 x 51 mm
10.04.012
Sensor
Frequency:
TX-power:
Lifetime:
Measurement range:
Measurement accuracy:
Operating temperature:
Dimensions:
Article number:
434.1 MHz
0 dBm
4 - 5 years
0 – 13 Bar
± 0.15 Bar
-40 °C ~ +125 °C
Ø 27,5 x 32,5 mm
10.01.040
External antenna
Cable length:
Connectors:
Frequency:
Installation bracket:
Article number:
10 m
TNC
434,1 MHz
Aluminium
10.01.043
tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com
Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com
10. tpm-systems AG
For OTR, Earth movers, Machines
Advantages:
• Realtime monitoring of pressure and temperature
• Improves operating safety and reduces down time
• Increases tyre life
• Fast and easy installation
• LCD monitor shows tyre pressure, temperature, sensor battery status
• Automatic warning, when tyre pressure above or below set thresholds
• Warning for low battery voltage (sensor)
• Logs alarms in memory
• Easy export of tyre pressure, temperature, alarms via USB-Port
• Additional sensors to upgrade the system
Delivery contents
Monitor with USB connector, sensors V12 (4 pieces)
Anti theft protection rings (4 pieces), user manual, wiring cables
tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com
Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com
w!
Ne
OTR-TPMS
11. tpm-systems AG
For OTR, Earth movers, Machines
Specifications
LCD-Monitor
Frequency:
Display:
Receiver sensitivity:
Operating temperature:
Operating voltage:
Dimensions (mm):
Article number:
434.1 MHz
LCD with
backlight
-105 dBm
-30 °C ~ +75 °C
12 V oder 24 V
173 x 102 x 53
10.06.011
Sensor
Frequency:
TX power:
Range:
Lifetime:
Measurement range:
Measuremen accuracy:
Operating temperature:
Dimensions:
Article number:
434.1 MHz
0 dBm
ca. 10 m
4 - 5 years
0 – 13 Bar
± 0.15 Bar
-40 °C ~ +125 °C
Ø 27,5 x 32,5 mm
10.06.040
tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com
Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com
w!
Ne
OTR-TPMS
12. tpm-systems AG
w!
Ne
Parkmatic Powerline
Reversing sensor with 7 warning zones
for trucks and trailers
Specially designed for long vehicles such as trucks and busses, modular and
flexibel; quick and easy installation. With Parkmatic Powerline you can use the
comfort and safety of a professional reversing sensor system with little installation effort for your own fleet.
Structure and function of the system
The system consists of two parts:
1) Sensorbox (ECU) with 4 sensors is installed at the rear end of the vehicle
and connected to the reversing light. Box is activated by reverse gear.
2) Optical and acoustic display Anzeige (LED with buzzer): The display will be
attached to the vehicle electrical. Data transmission is done via the vehicle
wire harness (“+”- line). No signal wirings are required!
Advantages:
✔ Very robust data transmission (powerline) from ECU to display
✔ Easy trailer change: LE9 display recognizes all connected ECUs.
✔ Digital sensors with extra large horizontal detection angle
✔ Very high and adjustable sensor sensitivity
✔ ECU and sensors are waterproof
The system structure is modular. You can decide if you want to monitor tractor
or trailer only or both. When hooking up the trailer the Parkmatic Sensors on
the tractor will be automatically disabled. A trailer change will be automatically
recognized.
Article-No.:
PM-6924
PM-6024
Description
4 sensors, LE9 display, ECU, wire harness
4 sensors, ECU, wire harness
tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com
Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com
13. tpm-systems AG
modular design, quick and
easy installation
System components
1 display / receiver unit LE9
4 digital sensors
1 ECU / transmitter unit
wire harness for ECU / sensors
Installation material
User guide / Installation manual
Article-No.:
PM-6924
Display / Receiver Unit LE9
Distance range:
22 cm .. 2,5 m
Last Zone selectable:
22, 50, 70 cm
Installation:
standing, hanging
Warning:
optical, acoustic
Operating voltage:
10,5 .. 28 VDC
Operating temperature:
-30 °C ~ +80 °C
Dimensions:
90 x 75 x 40 mm
Article-No.:
PM-LE9
ECU
Sensitivity:
Waterproof:
Trailer detection:
Operating voltage:
Operating temperature:
Dimensions:
Article-No.:
4 steps selectable
IP67
automatic
10,5 .. 28 VDC
-30 °C ~ +80 °C
137 x 86 x 34 mm
PM-H27A
Digital Sensors
Sensor type:
Detection angle:
Detection range:
Transmission:
Operating temperature:
Dimensions:
Article-No.:
active, 40 kHz
60 °
2,5 m
digital
-30 °C ~ +80 °C
210 x 110 x 30 mm
PM-S24A
tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com
Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com
w!
Ne
Parkmatic Powerline
14. tpm-systems AG
Tyre Repair and Prevention
Mobility warranty for emergencies
Flat tyre prevention: PremiumSeal Prevent
PremiumSeal Prevent effectively helps to prevent down time due to tyre punctures. Damages
of a tyre with up to 10 mm diameter will be immediately and effectively sealed. The tyre will
remain in driveable condition and can be saved.
At the same time the tyre sealant dynamically
balances the tyre, which reduces the stress on
the vehicle and the chassis as an aside.
Article.-No.:
PremiumSeal Prevent 1l:
PS-P
For the emergency: PremiumSeal Repair Kits
PremiumSeal tyre repair kits for the case of a
tyre puncture:
a proven and tested method which will help you,
too to always keep moving.
Article-Numbers:
PremiumSeal Truck-Set 1:
PremiumSeal Truck-Set 2:
PremiumSeal Comfort 1:
PremiumSeal Comfort 2:
PS-TS1
PS-TS2
PS-TC1
PS-TC2
tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com
Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com
15. tpm-systems AG
Q-Sensor and Accessories
Q-Sensor: the new little queue helper
Spare parts, installation materials
Q-Sensor: Use waiting times more useful
The new Q-Sensor keeps an eye out when you
are standing in line. Install on your windshield or
side mirror and connect to the cigarette lighter
and it will alert you when the gap in front opens
up. You are free to care about other things in the
meantime without losing touch with your queue
when things are moving again.
Article-No.:
PM-QS1
Valve extensions and clamps
Tyre pressure sensors may only be installed on
pressure proof valve extensions. We are providing essential installation materials for safely installing your tyre pressure sensors.
Article-Numbers:
Valve extension 45°:
Valve extension with clamp:
Valve extension 175 mm:
Clamp 16 mm width:
Clamp 26 mm width:
LPA-OWE
LPA-IWE
VL-175
FK-16
FK-26
Silica Gel Protection Cover
Protects LED pressure alarm of dirt and damage
Article-No.:
LPA-SP
T-joints and Adapters
For installation onto OTR-tyres and easier inflating and testing.
Article-Numbers:
T-Stück:
3-Wege Adapter:
OTR Ventil-Adapter:
LPA-TDT
AD-3W
LPA-OR
Spare parts
Any spare parts such as anti theft rings, allen
wrench, wire harness, installation bracket are
available as spare parts. Please contact us.
tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com
Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com
16. tpm-systems AG
Company profile
tpm-systems AG was founded in 2005 in Switzerland as specialist supplier for tyre pressure monitoring systems.
The founders combine substancial Know-How in
this area and their technology has been in use
since 1997 with designated auto manufacturers
in series production.
Since 2007 a mix of genuine products, complementary commercial products, product extensions
and accessories has been successfully introduced
in the market. Major brands are TireMoni,
Parkmatic and LED Pressure Alarm.
Since early 2009 tpm GmbH is responsible for
marketing the products in Germany and all other
EU countries.
The product portfolio is continuously developed to
market requirements and technological possibilities.
tpm GmbH, Gewerbepark 26, 86687 Kaisheim, www.tiremoni.com
Tel: 09099 / 966 4966, Fax: - 4969, Email: info@tiremoni.com